Clean food and pharmaceutical processing plant interior

在用建筑内喷砂,无需清场。

在用建筑、医院以及食品与制药工厂内喷砂:海绵磨料清洁和除漆,撞击时最高可截留95%的扬尘,不用水,不含结晶二氧化硅,因此相邻区域照常使用时,作业也能进行。

  • -95%

    撞击点扬尘

  • 5–30

    循环次数(按档位)

  • 0–25 µm

    纯海绵档至320#档

A hospital corridor under renovation, a clear plastic containment wall with a zipper door sealing off one section, the rest
难点

建筑里仍然有人。

医院、学校、办公楼、食品厂和制药厂,很少为了维修而清空。霉菌、烟熏损伤和失效涂层仍要处理,而且往往离病人、生产线或洁净室只有几米。

在这里,从作业区逸出什么,和喷砂去掉什么同样重要。

常规方法产生的,恰恰是这些场所不能接受的东西:隔壁房间里的悬浮颗粒、湿气或化学残留。

Timber floor joists and sheathing in an old building covered in dark mould staining and water marks, a damp concrete wall
  • 悬浮颗粒

    干式磨料喷砂和打磨把细粉送入空气,通风系统再把它带遍整栋建筑。

  • 湿气与霉菌

    湿式清洗会给结构添水,而这些结构可能本就在滋生霉菌。

  • 化学气味

    溶剂和脱漆剂在食品、病人或产品附近留下气味和残留。

解决方案

敏感场所的低扬尘清洁。

EcoSponge Blast保护档靠载体清洁;更硬的档位靠复合在内的磨粒切削。无论哪种,撞击时大部分扬尘被截留,过程保持干式,海绵磨料落在操作人员附近,便于回收。

Inside a negative-pressure enclosure of clear plastic sheeting in a food processing plant, an operator in white coveralls
DRY. LOW-DUST. LOCAL.
  • 干式作业

    没有水进入墙体或顶棚,不需要干燥,也不会给霉菌新的养分。

  • 不含结晶二氧化硅

    所有档位都不含结晶二氧化硅,对在场人员和员工的风险评估因此更简单。

  • 作业区更小

    反弹小,颗粒留在喷枪附近,负压围护可以保持紧凑。

  • 外运废料更少

    海绵磨料过筛后循环复用,需要穿过走廊运出的废料更少。

用在哪里

敏感场所,三类常见作业。

  • Operator in white coveralls sponge blasting mould staining off timber joists and sheathing under a floor with soft media,
    霉菌治理
    在搁栅、望板和混凝土上喷砂治理霉菌:保护档清除表面的霉菌和污渍,残物被截留,按治理方案清运。
  • Operator cleaning fire soot from a blackened brick wall and charred timber beam with fine sponge media, the cleaned area
    火灾与烟垢清理
    在木材、砌体和钢材上清理火灾烟垢,使用纯海绵档或细粒度档位清除烟熏残留,无需湿式清洗。
  • Operator sponge blasting a steel equipment support frame in a pharmaceutical plant hall next to stainless tanks, inside a
    食品、制药与医院
    在食品厂、制药厂和医院里,对地面、墙面、钢框架和设备支座除漆并重新涂装,旁边的区域照常运行。
作业流程

在用建筑内喷砂,逐间进行。

在照常使用的建筑内,作业班组如何安排作业。

  • A crew sets up clear plastic containment walls with a zipper door in a building corridor and connects a negative-air machine
  • Close view of very fine, gentle sponge media lifting staining off a painted wall without removing the coating underneath
  • An inspector in white coveralls checks the dry cleaned wall with a torch and takes a surface sample with a swab
  • A worker vacuums spent granules from the floor inside the enclosure while sealed white waste bags wait by the zipper door
  • 隔离

    封闭房间

    按场所要求设置围护、负压和标识;扬尘低,布置规模可以小。

  • 清理

    用最软的档位

    先用能完成作业的最温和的档位,只在必须去除涂层的地方改用细粒度氧化铝。

  • 核查

    核查表面

    表面即刻干燥,可以检查、取样或封闭,无需等待干燥。

  • 清运

    装袋回收

    海绵磨料吸起后过筛;霉菌或烟垢残物随废料部分装袋运出建筑。

An operator in white disposable coveralls and full-face respirator inside a clear plastic enclosure, nozzle in hand, a

在使用中的建筑内,海绵磨料让作业保持在局部:扬尘在撞击时被截留,不打湿任何东西,颗粒落在喷枪附近。每个区域如何隔离,仍由场所自己的感染控制、卫生或GMP规定决定。

应用说明

霉菌、烟垢与涂层清除 · 在用建筑

application note
开始试用
试用 EcoSponge Blast
就在你自己的工件上。

告诉我们你的本体、涂层和目标粗糙度。我们推荐合适的档位,寄出试用样品,并附技术资料和SDS安全数据表。